What triggered that Airbus emergency software recall? The BBC reports that Airbus's initial investigation into an aircraft's sudden drop in altitude linked it "to a malfunction in one of the aircraft's computers that controls moving parts on the aircraft's wings and tail." But that malfunction "seems to have been triggered by cosmic radiation bombarding the Earth on the day of the flight..."

The BBC believes radiation from space "could become a growing problem as ever more microchips run our lives."

> What Airbus says occurred on that JetBlue flight from Cancun to New Jersey was a phenomenon called a single-event upset, or bit flip. As the BBC has previously reported, these computer errors occur when high-speed subatomic particles from outer space, such as protons, [1]smash into atoms in our planet's atmosphere . This can cause a cascade of particles to rain down through our atmosphere, like throwing marbles across a table. In rare cases, those fast-moving neutrons can strike computer electronics and disrupt tiny bits of data stored in the computer's memory, switching that bit — often represented as a 0 or 1 — from one state to another. "That can cause your electronics to behave in ways you weren't expecting," says Matthew Owens, professor of space physics at the University of Reading in the UK. Satellites are particularly affected by this phenomenon, he says. "For space hardware we see this quite frequently."

>

> This is because the neutron flux — a measure of neutron radiation — rises the higher up in the atmosphere you go, increasing the chance of a strike hitting sensitive parts of the computer equipment on board. Aircraft are more vulnerable to this problem than computer equipment on the ground, although bit flips do occur at ground level, too. The increasing reliance of computers in fly-by-wire systems in aircraft, which use electronics rather than mechanical systems to control the plane in the air, also mean the risk posed by bit flips when they do occur is higher... Airbus told the BBC that it tested multiple scenarios when attempting to determine what happened to the 30 October 2025 JetBlue flight. In this case also, the company ruled out various possibilities except that of a bit flip. It is hard to attribute the incident to this for sure, however, because careering neutrons leave no trace of their activity behind, says Owens...

>

> [Airbus's software update] works by inducing "rapid refreshing of the corrupted parameter so it has no time to have effect on the flight controls", Airbus says. This is, in essence, a way of continually sanitising computer data on these aircraft to try and ensure that any errors don't end up actually impacting a flight... As computer chips have become smaller, they have also become more vulnerable to bit flips because the energy required to corrupt tiny packets of data has got lower over time. Plus, more and more microchips are being loaded into products and vehicles, potentially increasing the chance that a bit flip could cause havoc. If nothing else, the JetBlue incident will focus minds across many industries on the risk posed to our modern, microchip-dependent lives from cosmic radiation that originates far beyond our planet.

[2]Airbus said their analysis revealed "intense solar radiation" could corrupt data "critical to the functioning of flight control." But that explanation "has left some space weather scientists scratching their heads," adds the BBC.

[3] Space.com explains :

> Solar radiation levels on Oct. 30 were unremarkable and nowhere near levels that could affect aircraft electronics, Clive Dyer, a space weather and radiation expert at University of Surrey in the U.K., told Space.com. Instead, Dyer, who has studied effects of solar radiation on aircraft electronics for decades, thinks the onboard computer of the affected jet could have been struck by a cosmic ray, a stream of high-energy particles from a distant star explosion that may have travelled millions of years before reaching Earth. "[Cosmic rays] can interact with modern microelectronics and change the state of a circuit," Dyer said. "They can cause a simple bit flip, like a 0 to 1 or 1 to 0. They can mess up information and make things go wrong. But they can cause hardware failures too, when they induce a current in an electronic device and burn it out."



[1] https://www.bbc.com/future/article/20221011-how-space-weather-causes-computer-errors

[2] https://www.airbus.com/sites/g/files/jlcbta136/files/2025-11/airbus_update_on_a320_family_precautionary_fleet_action.pdf

[3] https://www.space.com/technology/aerospace/cosmic-ray-forces-airliner-emergency-landing